NHTSA tire-safety data for the Chevrolet G20: recall notices matched to its factory tire fitment, plus owner-reported complaint volume. Recalls require a free remedy; complaints are unverified owner reports. Both are shown so you can judge the full safety picture.
4 tire-related recall notices on record for tires matched to this vehicle's factory fitment. Review each notice below and check your specific tire's DOT code against the campaign.
NHTSA campaigns
Tire recall notices matched to this vehicle
Each notice below is an NHTSA recall on a tire that matches one of this vehicle's factory fitment sizes (match confidence ≥ 0.5). A recall on a tire model does not mean every unit is defective; check the DOT date code on your sidewall against the campaign's affected production window.
Summary. Hankook Tire America Corp. (Hankook) is recalling certain Kinergy GT tires, size 235/60R18H H436. The tires contain a tire identification number (TIN) that is missing the 4-digit week and year code mark. As such, these tires fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 574, "Tire Identification & Recordkeeping."
Consequence. Missing TIN information can make it difficult for tire owners to identify a tire involved in a recall. Owners may continue to drive on recalled tires, increasing the risk of a crash.
Remedy. Dealers will replace the tires, free of charge. The affected vehicle manufacturer will mail letters to owners. Owners may contact Hankook customer service at 1-800-426-5665.
Summary. Hankook Tire America Corp. (Hankook) is recalling certain Kinergy GT (H436) tires, size 235/50R19H with DOT code 0521. The tires may have been manufactured with an insufficient amount of curative agent, which could cause tread separation.
Consequence. Tread separation can result in tire failure and a loss of vehicle control, increasing the risk of a crash.
Remedy. Dealers and authorized independent service centers will replace the affected tires, free of charge. Owner notification letters were mailed on July 15, 2021. Owners may contact Hankook customer service at 1-800-426-5665.
{"subject":"Tires May Develop Cracks in Sidewall","potentially_affected":"46968"}
Reported
2015-12-22
Summary. Hankook Tire America Corp. (Hankook) is recalling certain Ventus S1 Noble 2 tires, size 245/45R18 96W, manufactured May 20, 2013, to February 14, 2015, and size 245/40R19 94W and 275/35R19 96W tires manufactured May 22, 2013, to February 14, 2015 supplied for 2015 Hyundai Genesis vehicles as well as being sold as replacement tires. The affected tires may develop cracks in the tire sidewall, resulting in a loss of air.
Consequence. A loss of tire pressure may cause tire failure and a loss of vehicle control, increasing the risk of a crash.
Remedy. Hankook will notify the purchasers of the replacement tires and Hankook dealers will pay or credit the cost of the tire, free of charge. Owners of affected Hyundai vehicles will be notified by Hyundai and Hyundai dealers will replace the tires, free of charge. The recall began on December 18, 2015. Owners may contact Hankook customer service at 1-800-426-5665.
Summary. HANKOOK TIRE AMERICA CORP. (HTAC) IS RECALLING CERTAIN TIRES, SIZE P265/70R17S RH03, SOLD AS REPLACEMENT TIRES FOR PASSENGER VEHICLES. THE SUBJECT TIRES EXPERIENCED LESS THAN EXPECTED SIDEWALL PERFORMANCE DURING INTERNAL TESTING.
Consequence. THE SIDEWALL OF THE TIRES CAN WEAR PREMATURELY AND/OR EXPERIENCE A BLOW-OUT, INCREASING THE RISK OF A CRASH.
Remedy. HATC WILL SEND NOTICES TO ALL OWNERS OF RECORD AND REPLACE THE TIRES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 27, 2010. OWNERS MAY CONTACT HANKOOK TIRE AT 1-855-275-8899.
The recalls above matched tires offered in the following OEM size for the Chevrolet G20. Confirm your size against the driver-door placard.
235/75R15
NHTSA-reported issues for chevrolet G20
2
Complaints
0
Crashes
0
Injuries
0
Deaths
Top issue category:Tires (General)
Reported across: 1996 – 1996 (1 year)
What owners described
Blowout or sudden deflation appears in 50% of these reports; about 2.5× as often as across all tire complaints. Percentages are shares of the 8 reports covering every model year of the Chevrolet G20 that include a written account; a single report can describe more than one problem, so they do not total 100%.
Reported problem
This subject
All tire complaints
Relative
Blowout or sudden deflation
50%
20%
2.5×
Tread or belt separation
38%
13%
2.8×
Loss of control, rollover or collision
13%
8%
1.5×
Mileage at failure
6 of these reports state an odometer reading. The middle report is at 43,959 miles, with 8 in 10 falling between 4,000 and 140,000 miles.
In owners' own words
Verbatim excerpts from complaints filed with NHTSA about Chevrolet G20. Reports are published by NHTSA as filed and are lightly cleaned here only to remove intake codes.
IN 1991 CONSUMER PURCHASED A FULL SET OF BRIDGESTONE, DUELERS. TWO OF THE TIRES WERE MOUNTED, ABOUT TWO YEARS LATER, WHILE DRIVING AT 60 MPH, ONE OF THE TIRES BLEW OUT. FOUR YEARS LATER, THE SECOND TIRE BLEW OUT. ALSO, A COUPLE OF MONTHS LATER, THIRD TIRE SUFFERED AN INTERNAL FAILURE, WHICH CAUSED THE TIRE TO LOSE IT'S FLATNESS AND BECOME "V" SHAPED. CJBECOME "V" SHAPED. CJ
NHTSA complaint 262257 · 1971 vehicle
WHILE DRIVING, VEHICLE WOULD WANDER SIDE TO SIDE AND PULL TO SIDE. SOMETIMES COULD FLIP OVER. THEN, TOOK VEHICLE TO DEALER, AND THEY FOUND TREAD SEPARATION. FIRESTONE, FIREHAWK TIRES. *AK CONSUMER STATES WHEN VEHICLE WAS TAKEN IN FOR REGULAR MAINTENANCE IT WAS DISCOVERED THAT ALL FOUR TIRES WERE FOUND TO HAVE BROKEN BELTS AND TIRES WERE UNABLE TO BE ROTATED, BALANCED OR ALIGNED, CONSUMER WAS ADVISED BY MECHANIC TO GO TO FIRESTONE ABOUT THE TIRES, WHEN CONSUMER ARRIVED SHE WAS TOLD THEY HAD TOO MANY VEHICLES TO SERVICE. CONSUMER ALSO WAS ADVISED THAT BRAKES WERE NEEDED.
NHTSA complaint 277915 · 1997 vehicle
ON 7-5-01 AT APPROXIMATELY 7:15 PM WHILE PARKED IN A GROCERY STORE PARKING LOT I HEARD A LOAD EXPLOSION. SUDDENLY THE LEFT FRONT CORNER OF THE VEHICLE SETTLED DOWN. I KNEW AT THIS TIME THAT THE LEFT FRONT TIRE SUFFERED A RAPID AIR LOSS. SEARS ROEBUCK SELLER OF THE TIRE BLAMES A ROAD HAZARD. NO INDICATION OF SUCH, HAD NOT HIT ANY POTHOLES OR OBSTACLES IN THE ROADWAY. VEHICLE USED ON HARD SURFACED ROADWAYS ONLY. (DOT NUMBER: HYHF REL TIRESIZE: P21575S15)
NHTSA complaint 302827 · 1994 vehicle
THE CONTACT OWNS A 1985 CHEVROLET G20, WITH COOPER WEATHER- MASTER ST STEEL P225/75/R15 TIRES. WHILE DRIVING 75 MPH THE DRIVER-SIDE FRONT TIRE TREAD SEPARATED. HE REPLACED THE FAILED TIRE WITH THE SPARE TIRE; HOWEVER, 15 MILES LATER, THE DRIVER-SIDE REAR TIRE BLEW OUT AND CAUSED THE VEHICLE TO ROLL OVER AND CRASH. THE POLICE AND EMS WERE NOTIFIED. HE SUSTAINED INJURIES TO THE HEAD AND EXTENSIVE BRUISING ON HIS ENTIRE BODY. A POLICE OFFICER CONCLUDED THAT BECAUSE THE SIDE-WALLS WERE SPLIT, THE TIRES WERE DEFECTIVE. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 140,000.
NHTSA complaint 737375 · 1985 vehicle
Complaints are voluntarily submitted to the NHTSA Office of Defects Investigation and are not verified by NHTSA; they represent owner-reported problems, not proven defects. Counts can be useful as a relative quality signal across comparable tires or vehicles.
What to do if a tire on your vehicle is recalled
Find your tire's DOT code. The DOT date code is on the tire sidewall; the last four digits are the week and year of manufacture (e.g. 2419 = week 24 of 2019). Recalls apply to specific production windows, so this tells you whether your tire is in scope.
Check the campaign. Enter the NHTSA campaign number (linked in each notice above) at the free NHTSA recall lookup, or search by your tire brand and model.
Claim the free remedy. Under U.S. law, a recalled tire is remedied at no cost by the manufacturer; typically free replacement. Contact the tire maker or the dealer that sold the tire; you do not pay for a recall remedy.
Register your tires. Registering with the manufacturer (tire shops can do this at install) means you are notified directly of future recalls instead of finding out by chance.
Yes; there are 4 tire-related recalls on record matched to the Chevrolet G20's factory tire fitment. Each notice above links to its NHTSA campaign. Recalls apply to specific production windows, so check the DOT date code on your sidewall.
How do I check if my tire is recalled?
Read the DOT date code on the sidewall (the last four digits are the week and year of manufacture), then enter the NHTSA campaign number or your tire brand and model at the free NHTSA recall lookup. Recalls cover specific production windows, so the date code determines whether your tire is affected.
What do I do if my tire is recalled?
A recalled tire is remedied at no cost; usually free replacement by the manufacturer. Contact the tire maker or the dealer that sold it. You never pay for a recall remedy under U.S. law.
Are tire complaints the same as a recall?
No. This vehicle has 2 tire-related owner complaints filed with NHTSA, but complaints are voluntary reports of problems; not verified defects and not a recall. A recall is an official campaign requiring a free remedy. Complaint volume is a useful relative quality signal, not proof of a defect.
Sources
Last verified 2026-09-02 against the sources below.
